Estimation of energy characteristics of the asynchronous motor with a combined winding
https://doi.org/10.30724/1998-9903-2021-23-6-109-118
Abstract
PURPOSE. Asynchronous motors are the main consumers of the electrical energy. Increasing their energy performance can contribute to a significant reduction in energy consumption in general. Using a combined 12-zone winding instead of the standard 6-zone one theoretically can lead to a decrease in electrical losses in the stator winding of the asynchronous motor and to reduce additional losses caused by the higher spatial harmonics. The main purpose of the work is to assess the effect of using a combined winding stator on the energy characteristics of the induction motor.
METHODS. The study was performed on two AIR71V4 electric motors, one of which had a standard winding and the other had a combined winding. In the experiment, the engines were rated voltage, and the load was carried out using an electromagnetic loading device. The engines were tested in the range of loads from idle to the nominal. The experiment was performed five times.
RESULTS. The work under analysis shows the dependences of the current strength, consumed active and reactive power, efficiency, and power factor from engine load.
CONCLUSION. The results of the study showed that an asynchronous motor with the combined winding over the entire investigated range of loads has a lower consumption of both active and reactive power, compared to a motor with a standard winding, while the power factors of these motors are practically the same. The greatest difference in efficiency was observed at loads lower than the nominal in favor of an improved engine model, but also at rated load, the motor with a combined winding has the higher efficiency of 3,1%.
About the Authors
K. V. Martynov
Izhevsk State Agricultural Academy
Russian Federation
Russian Federation
Izhevsk
L. A. Panteleeva
Izhevsk State Agricultural Academy
Russian Federation
Russian Federation
Izhevsk
I. A. Blagodatskih
Izhevsk State Agricultural Academy
Russian Federation
Russian Federation
Izhevsk
References
1. Abdullazyanov EYu, Gracheva EI, Gorlov AN, Shakurova ZM, Tabachnikova TV, Valtchev S. Algorithms for estimating equivalent resistances of in-plant electrical networks. Power engineering: research, equipment, technology. 2021;23(4):3-13. doi:10.30724/1998-9903-2021- 23-4-3-13.
2. Meshcheryakov VN, Sibirtsev DS, Valtchev S, Gracheva EI. Control system for a frequency synchronized asynchronous electric drive. Power engineering: research, equipment, technology. 2021;23(3):116-126. doi:10.30724/1998-9903-2021-23-3-116-126.
3. Ivanovа VR, Kiselev IN. Frequency-adjustable electric drive for energy saving and optimization of technological processes in electrical complexes. Power engineering: research, equipment, technology. 2019; 21(5):59-70. doi:10.30724/1998-9903-2019-21-5-59-70.
4. Romanova VV, Khromov SV, Suslov KV. Analysis of influencing factors affecting the operational reliability of low-voltage asynchronous electric motors. Power engineering: research, equipment, technology. 2021;23(3):80-89. doi:10.30724/1998-9903-2021-23-3-80-89.
5. Mugalimov RG, Barankova II, Zakirova RA, Mugalimova AR, Mikhaylova UV, Nikiforov GV. Tekhniko-ekonomicheskoye obosnovaniye tselesoobraznosti kapital'nogo remonta asinkhronnykh dvigateley s povysheniyem ikh energoeffektivnosti. Vestnik Magnitogorskogo gosudarstvennogo tekhnicheskogo universiteta im. G.I. Nosova. 2017; 2:101-9.
6. Vansompel H., Sergeant P., Dupre L., et al. A Combined Wye-Delta Connection to Increase the Performance of Axial-Flux PM Machines with Concentrated Windings. IEEE Trans. Energy Convers. 2012;2:403-10.
7. Chen JY., Chen CZ. Investigation of a new AC electrical machine winding. IEE Proceedings - Electric Power Applications. 1998;2:125-32.
8. Cistelecan MV., Ferreira FJTE., Popescu M. Adjustable Flux Three-Phase AC Machines with Combined Multiple-Step Star-Delta Winding Connections. IEEE Transactions on Energy Conversion. 2010;2:348-55.
9. Gwozdziewicz M., Gawron S. Application of star-delta mixed stator winding in synchronous machine, with permanent magnets on the rotor surface. Prace Naukowe Instytutu Maszyn, Napędowi Pomiarow Elektrycznych. 2011;65:55-63.
10. Kasten H. Wirkungs gradsteigerung von Asynchronmaschinen durch den Einsatzeiner Wicklung mit Stern-Dreieck-Mischschaltung. Jahresbercht. 2010;76-82.
11. Martynov KV., Noskov VA., Panteleeva LA. Sovershenstvovaniye konstruktsii obmotki statora asinkhronnogo dvigatelya. Vestnik VIESKH. 2017;1(26):5-12.
12. Martynov KV., Noskov VA. Garmonicheskiy analiz magneto dvizhushchey silya sinkhronnogo dvigatelya s sovmeshchonnoy obmotkoy. Materialy Mezhdunarodnoy nauchnoprakticheskoy konferentsii Instituta agroinzhenerii «Razvitiye energosistem APK: perspektivnyy etekhnologii»; 03–06 Apr 2018; Chelyabinsk, Russia. Troitsk: Yuzhno-Uralskiy GAU, 2018. pp. 94-101.
13. Martynov KV., Noskov VA. Garmonicheskiy analiz magnitodvizhushchey sily asinkhronnogo dvigatelya s raspredelonnoy sovmeshchonnoy obmotkoy. Materialy Mezhdunarodnoy nauchno-prakticheskoy konferentsii «Innovatsionnyy etekhnologii dlya realizatsii programmy nauchno-tekhnicheskogo razvitiya selskogo khozyaystva»; 13–16 Feb 2018, Izhevsk, Russia. Izhevsk: Izhevskaya GSKHA, 2018. pp. 151-156. Проблемы энергетики, 2021, том 23, № 6 118
14. Noskov VA., Panteleeva LA., Martynov KV. Improving the Efficiency of АlternatingCurrent Machine Windings. Russian Electrical Engineering. 2018;89(1):32-35. – doi:10.3103/S106837121801011X.
15. Martynov KV., Noskov VA., Panteleeva LA. et al. Perspektivy primeneniya sovmeshchonnoy obmotki dlya snizheniya elektricheskikh poter v statore. AgroEcoInfo. 2020;1(39).
16. Boyko YeP, Ganitsev YuV, Kovalev YuM etc.; Petrov VM, Kravchik AE., editors. Asinkhronnyye dvigateli obshchego naznacheniya. Moscow: Energiya; 1980. (In Russ).
17. Heller B, Hamata V. Harmonic field effects in induction machines. Prague: Academy of Sciences; 1977.
18. Vanurin VN. Statornyye obmotki asinkhronnykh mashin. Saint Petersburg: Lan'. 2014.
19. Martynov KV., Noskov VA., Blagodatskikh IA. Programma pereraschota obmotki statora mashiny peremennogo toka so standartnoy 6-zonnoy na sovmeshchonnuyu 12-zonnuyu. Computer program №2020662822. 28.10.2020, Byul. № 11.
Review
For citations:
Martynov K.V., Panteleeva L.A., Blagodatskih I.A. Estimation of energy characteristics of the asynchronous motor with a combined winding. Power engineering: research, equipment, technology. 2021;23(6):109-118. (In Russ.) https://doi.org/10.30724/1998-9903-2021-23-6-109-118
Views:
342
Email this article 