DIELECTRIC COATINGS AND THEIR EFFECT ON CORROSION PROTECTION OF THE OUTER SURFACE OF UNDERGROUND PIPELINES
https://doi.org/10.30724/1998-9903-2018-20-1-2-80-89
Abstract
This paper presents comparative analysis of influence of main factors, determining characteristics of dielectric coatings, both on the corrosion of underground metal pipelines and on their cathodic protection. At the same time, it was identified that, as a priority approach in the development of coatings to protect pipelines in the ground (without the use of cathodic protection), it is necessary to choose to reduce the electrical conductivity of the coatings as a result of their saturation with soil electrolyte. This measure significantly reduces the efficiency of corrosion elements that are likely to occur when dielectric coating is damaged. As for priority in the development of coatings for combined protection of pipelines in the ground, it is necessary to increase the mechanical strength of coatings and to implement a set of measures to prevent the formation of insulation defects and to eliminate them. Actions taken in this direction significantly reduce the amount of protective current necessary for active corrosion protection of underground metal structures.
About the Authors
V. G. Kiselev
Peter the Great Saint-Petersburg Polytechnic University
Russian Federation
Russian Federation
Vladimir G. Kiselev - Dr. Sci. (Tech.), prof. of the department Nuclear and Heat Power Engineering
E. N. Ruzich
Peter the Great Saint-Petersburg Polytechnic University
Russian Federation
Russian Federation
Evgenij N. Ruzich - PhD student of the department Nuclear and Heat Engineering
References
1. Stefan Sanft, Markus Thewes. Wirtschaftlichkeits bewertung von Instandhaltungs strategien bei Gasverteilnetzen. 3R International, 2016, No. 10-11, P. 45-52.
2. Ulrich Bette. Ergebnisse des Feldversuchens an einer durch Bahnwechselstrom beeinflussten Rohrleitung. 3R International, 2016, No. 6, P. 40-45.
3. Muradov A.V. Some features of realization of joint electric protection / A.V. Muradov, G.G. Ismajlova, A.A. Hasanov // Neft', gaz i biznes. 2014. No. 4. P. 61-63.
4. Muradov, A.V. Joint protection of two underground structures / A.V. Muradov, G.G. Ismajlova, A.A. Hasanov // Neft', gaz i biznes. 2012. No. 4. P. 44-46.
5. W. v. Baeckmann, R. Jakob.Korrosionsschutz von Gas-und Wasserrohrleitungen / Baeckmann W. v., Jakob R. // Vulkan-Verlag Essen. 1995. P. 82.
6. Ulrich Bette. Taschenbuch für den kathodischen Korrosionsschutz / Ulrich Bette, Wolfgang Vesper // Vulkan-Verlag Essen. 2005. P. 367.
7. Baeckmann W. Handbuch des kathodischen Korrosionsschutzes / W. von Baeckmann und W. Schwenk // VerlagChemie. 1980. P. 465.
8. Kiselev V.G. Influence of the specific electric soil resistance on the selection of the form of cathode protection of underground conduits // Nauchno-tehnicheskie vedomosti SPbGPU. 2015. No. 3 (226). P. 17-26.
9. Kiselev V. G. Influence of the cover layer of underground metallic construction on the efficiency of cathode protection / V.G. Kiselev, A.A. Kaljutik // Izvestiya vuzov. Problemy energetiki. 2016. No. 5-6. P. 27-36.
10. Kiselev V.G. The influence of soil resistivity in the area of underground pipeline on the efficiency of cathodic protection / V.G. Kiselev, A.A. Kaljutik // Izvestiya vuzov. Problemy energetiki. 2015. No. 11-12. P. 48-55.
Review
For citations:
Kiselev V.G., Ruzich E.N. DIELECTRIC COATINGS AND THEIR EFFECT ON CORROSION PROTECTION OF THE OUTER SURFACE OF UNDERGROUND PIPELINES. Power engineering: research, equipment, technology. 2018;20(1-2):80-89. (In Russ.) https://doi.org/10.30724/1998-9903-2018-20-1-2-80-89
Views:
2556
Email this article 